NTO-200 Operation Manual RTI Technologies, Inc. 10 Innovation Drive York, PA 17402 USA Phone: 717-840-0678 Equ
9 REPLACING MEMBRANE CARTRIDGE When the cartridge’s usable life is diminished, (code E6 will be on the display) it will need to be replaced. Discon
10MAINTENANCE There are no serviceable parts on the NTO-200. The NTO-200 should be wiped down with a damp cloth only. Keep excessive moisture from
11ERROR MESSAGES The warnings below will appear on the display when NTO-200 is operated outside the limits specified in the technical specifications
12TROUBLESHOOTING Fault Probable Cause Solution NTO-200 will only power up for 5 seconds. An error occurred during operation Power up generato
13TROUBLESHOOTING (Continued) Fault Probable Cause Solution Compressed air supply does not meet specified requirements of ISO 8573-1: 2001 Cla
14RTI ONE-YEAR NTO-200 LIMITED WARRANTY (Applies only to equipment owned and operated in North America) During the One-Year Warranty period, RTI Tec
15WARRANTY (Continued) 4. DISCLAIMER THE EXPRESS WARRANTY HEREIN IS IN LIEU OF ANY AND ALL OTHER WARRANTIES, EXPRESSED OR IMPLIED. NO IMPLIED WARRAN
1TABLE OF CONTENTS Pictograms... 2 Safety Information ...2 Components
2PICTOGRAMS The following symbols will be used in this manual and found on the equipment: SAFETY INFORMATION GENERAL SAFETY Correct use of the NTO-2
3SAFETY INFORMATION (Continued) COMPRESSED AIR Warning: Ensure that the feed air pressure does not exceed 160 psig. The user is ultimately respons
4COMPONENTS When the NTO-200 is delivered, check the box to ensure that all items are included. The following is a list of includ
5INTRODUCTION The NTO-200 is a hand held, battery powered nitrogen tire inflation system created primarily for tire top-offs and small tire fills suc
6OVERVIEW KEY 1 Compressed Air Inlet 6 Exchangeable cartridge 11 Error Icon 2 ON / OFF and air release button 7 Nitrogen fillin
7CHANGING DISPLAY UNITS Warning: Ensure the NTO-200 is relieved of pressure before changing units. The membrane cartridge must be removed from gr
8 INFLATING TIRES Warning: The maximum tire pressure capability for the NTO-200 is 5.5bar / 80psi / 0.55MPa. Small tire sizes inflate very quickl
Comments to this Manuals